The Quantitative Analysis of Ethanol-based Hand Sanitizers and Prediction of Methanol Adulteration Using FTIR-ATR Technique

Anuj Garg^1,

¹Department of Chemistry, S.S.V. College, Hapur-245101 (U.P.), India

Cite this paper

Anuj Garg. The Quantitative Analysis of Ethanol-based Hand Sanitizers and Prediction of Methanol Adulteration Using FTIR-ATR Technique. World Journal of Chemical Education. 2023; 11(2):13-16. doi: 10.12691/WJCE-11-2-2

Abstract

Background - In this paper, a spectroscopic method is used to quantify the methanol and ethanol together present in the hand sanitizers with the help of the FTIR-ATR spectrometer using the Beers law quant method. Objective- The aim of this study is to determine the content of methanol as an adulterant in the ethanol-based hand sanitizers which are commercially available in the local market of Hapur with the help of FTIR –ATR technique. Method- In order to find out the methanol, seven synthetic hand sanitizers of ethanol contaminated with methanol were prepared and three for cross-validation as per the formulation of WHO for hand sanitizers. The calibration curves were constructed using Beers law by finding the peak area in the range 1020-1022 cm^-1 & 1044-1046 cm^-1 for methanol and ethanol respectively using Quant software. The linear curves so obtained have shown the correlation coefficient 0.997 and 0.996 for methanol and ethanol respectively. Five branded ethanol-based hand sanitizers were analyzed by FTIR-ATR. Result-The analysis of the locally purchased hand sanitizers shows less content of ethanol than claimed in most of them. However, none of the brands shows the presence of methanol as an adulterant. The validity of the method can be verified by the three synthetic sanitizers which were adulterated by methanol. Conclusion- With the widespread of Covid-19 the presence of methanol in hand sanitizers cannot be ruled out which can be harmful to health. In this paper, we have used a technique that is fast, cost-effective, and accurate to evaluate the adulteration of methanol in hand sanitizers.

Keywords

ethanol-based hand sanitizers, COVID-19, FTIR-ATR, beers law, methanol adulteration

Copyright

This work is licensed under a Creative Commons Attribution 4.0 International License. To view a copy of this license, visit http://creativecommons.org/licenses/by/4.0/

References

[1]	Lai, C.C., Shih, T.P., Ko, W. C., Tang, H. J., Hsueh, P. R., Severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) and coronavirus disease-2019 (COVID-19): the epidemic and the challenges. International Journal of Antimicrobial Agents. 2020, 55, 105924.
[2]	Kratzel, A., Todt, D., V'kovski, P., et al. Inactivation of Severe Acute Respiratory Syndrome Coronavirus 2 by WHO-Recommended Hand Rub Formulations and Alcohols. Emerging Infectious Disease. 2020; 26(7), 1592-1595.
[3]	WHO-recommended hand rub formulations in WHO Guidelines on Hand Hygiene in Health Care, PART-1, chapter 12, page 49. Available from https://apps.who.int/iris/bitstream/handle/10665/44102/9789241597906_eng.pdf; jsessionid=9224D1E17D7B01D0C7A40D1DE7957F99?sequence=1.
[4]	US food and Drug Administration. Available from https://www.fda.gov/drugs/drug-safety-and-availability/fda-updates-hand-sanitizers-consumers-should-not-use.
[5]	Wang, M. L., Wang, J. T., Choong, Y. M., Simultaneous quantification of methanol and ethanol in alcoholic beverage using a rapid gas chromatographic method coupling with dual internal standards. Food Chemistry. 2004, 86, 609-615.
[6]	Wang, M. L., Choong, Y. M., Su, N.W., Le, M. H., A rapid method for determination of ethanol in alcoholic beverages using capillary gas chromatography. Journal of Food & Drug Analysis. 2003, 11, 133-140.
[7]	Fletcher, P. J., Van, S. J. F., Determination of ethanol in distilled liquors using sequential injection analysis with spectrophotometric detection. Analytica Chimica Acta. 2003, 499, 123-128.
[8]	Bozkurt, S. S., Merdivan, E., Benibol, Y., A fluorescent chemical sensor for ethanol determination in alcoholic beverages. Microchim Acta. 2010, 168; (1-2): 141-145.
[9]	Sivakesava, S., Irudayaraj, J., Classification of Simple and Complex Sugar Adulterants in Honey by Mid-Infrared Spectroscopy. International Journal of Food Science and Technology. 2002, 37, 351-360.
[10]	Wang, J., Kliks, M. M., Jun, S., Jackson, M., Li, Q. X., Rapid Analysis of Glucose, Fructose, Sucrose, and Maltose in Honeys from Different Geographic Regions Using Fourier Transform Infrared Spectroscopy and Multivariate Analysis. Journal of Food Science. 2010, 75, C208-C214.
[11]	Debebe, A., Abshir, M. R., Chandravanshi, B. S., Non-destructive determination of ethanol levels in fermented alcoholic beverages using Fourier transform mid-infrared spectroscopy. Chemistry Central Journal. 2017, 11:27.
[12]	Coldea, T. E., Socaciu, C., Fetea, F., Ranga, F., Pop, R. M., Florea, M., Rapid Quantitative Analysis of Ethanol and Prediction of Methanol Content in Traditional Fruit Brandies from Romania, using FTIR Spectroscopy and Chemometrics. Notulae Botanicae Agrobotnici Cluj-Napoca. 2013,41(1), 143-149.
[13]	Lachenmeier, D. W., Rapid quality control of spirit drinks and beer using multivariate data analysis of Fourier transform infrared spectra. Food Chemistry. 2007, 101(2); 825-832.